Product ID:1220WZ EPOXY RUST-MATE ALUMINUM
MSDS Date:03/26/1996
FSC:6850
NIIN:00F048008
MSDS Number: BZDTM

ZYNOLYTE PRODUCTS CO

2320 E DOMINGUEZ ST
CARSON, CA 90749-5000
US

Emergency Phone: 213-513-0700/303-623-5716

Info Phone: 213-513-0700

Preparer: JOHN R KORDOSH

Cage: 25461

ZYNOLYTE PRODUCTS CO

6244 CARSON, CA 90749 US

Telephone: 310-513-0700

Cage: 25461

BUTANE, N-BUTANE

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 11%

OSHA PEL 1000 PPM

ACGIH TLV: 800 PPM

STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 8%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

ISOBUTANE, 2-METHYLPROPANE

CAS: 75-28-5

RTECS: TZ4300000

Fraction By Weight: 5%

OSHA PEL 1000 PPM

ACGIH TLV: 800 PPM

TOLUENE (IARC CARC- GROUP 3) *96-1*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 40-50%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ALUMINUM (POWDER) *96-1*

CAS: 7429-90-5

RTECS: BD0330000

Fraction By Weight: 2%

OSHA PEL 15 MG/CUM

ACGIH TLV: 10 MG/CUM (DUST)

V M & P NAPHTHA, LIGROINE, MINERAL SPIRITS *96-1*

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: 1%

OSHA PEL 500 PPM

ACGIH TLV: 300 PPM

SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH

CAS: 64742-95-6

RTECS: WF3400000

Fraction By Weight: 1-5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

ACETONE; DIMETHYL KETONE; 2-PROPANONE

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 29%

OSHA PEL 750 PPM

ACGIH TLV: 750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PROPANE (DIMETHYLMETHANE) *96-1*

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 16%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE

CAS: 64742-89-8

Fraction By Weight: 12%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE NOSE & THROAT
IRRITATION, NERVOUS SYSTEM DEPRESSION. EYES: IRRITATION & BURNING.
SKIN: IRRITATION & DERMATITIS. ORGANIC SOLVENTS ARE EASILY
ABSORBED. INGESTION: MAY CAUSE INFLAMM ATION, DAMAGE/DEATH.
REPEATED/PROLONGEDOVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE.(SUPP
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
STAGGERING GAIT, LASSITUDE, LOSS OF COORDINATION, CONFUSION,
UNCONSCIOUSNESS, BURNING, DISCOMFORT, EYE WATERING, DIZZINESS,
DRYNESS, REDNESS, DEFATTING, DISTRE SS, VOMITING, INFLAMMATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN &
RESPIRATORY DISORDERS.

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR, PREFERABLY MOUTH
TO MOUTH. EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS.
SKIN: WASH W/SOAP & WATER. INGESTION: DON'T INDUCE VOMITING, KEEP
HEAD LOWE R THAN WAIST. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:TCC
Flash Point:-256F
Lower Limits:1
Upper Limits:13
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:AVOID CONFINED SPACES. WEAR FULL PROTECTIVE
EQUIPMENT & A POSITIVE PRESSURE NIOSH APPROVED SCBA. WATER MAY BE
UNSUITABLE FOR EXTINGUISHING FIRE. KEEP COOL.(SUPP
Unusual Fire/Explosion Hazard:VAPORS ARE > THAN AIR & ACCUMULATE IN LOW
AREAS OF POOR VENTILATION/TRAVEL ALONG GROUND TO IGNITION SITES.
HEAT/SUNLIGHT MAY CAUSE CANS TO BURST & PROPELL.(SUPP

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION &
HOT METAL SURFACES. WEAR APPROPRIATE CLOTHING & GEAR. PREVENT SKIN
CONTACT & AVOID BREATHING OF VAPOR. CONFINE IMMEDIATELY & REMOVE
W/INERT ABSORBENT SUCH AS CLAY/SAND.

Handling and Storage Precautions:KEEP AWAY FROM ALL IGNITION SOURCES.
CAP CONTAINER AFTER EACH USE. DON'T STORE >120F. STORE IN DRY, WELL
VENTILATED PLACE. OBSERVE LABEL PRECAUTIONS.
Other Precautions:DON'T EXPOSE TO DIRECT SUNLIGHT. DON'T SPRAY NEAR
FIRE/FLAME. DON'T TAKE INTERNALLY. AVOID CONTACT. DON'T PUNCTURE
CONTAINERS. USE W/ADEQUATE VENTILATION-DON'T INHALE VAPORS. DON'T
SAND, FLAME CUT, BR AZE/WLD DRY W/O PROPER EQUIPMENT. (SUPP)

Respiratory Protection:IF THE TLV/PEL LIMITS ARE EXCEEDED, WEAR A
PROPERLY FITTED VAPOR & PARTICULATE/POSITIVE PRESSURE AIR SUPPLIED
RESPIRATOR APPROVED BY NIOSH/MSHA FOR USE W/PAINTS DURING
APPLICATION & UNTIL ALL VAPORS & SPRAY MISTS ARE EXHAUSTED.
Ventilation:SUFFICIENT TO KEEP CONTAMINANTS < APPLICABLE EXPOSURE
LIMITS. USE ONLY EXPLOSION PROOF EQUIPMENT W/FLAMMABLE MATERIALS.
Protective Gloves:NEOPRENE
Eye Protection:GOGGLES/SAFETY GLASSES W/SPLASH GUARD
Other Protective Equipment:SIDE SHIELDS/FACE SHIELD, PROTECTIVE CREAMS
FOR EASE OF CLEANUP. APRON/COVERALLS/WORK CLOTHES/EYE WASHS/SAFETY
SHOWERS.
Supplemental Safety and Health

Boiling Pt:B.P. Text:(SEE SUPP)
Vapor Density:>1
Spec Gravity:0.71
VOC Grams/Liter:4.59
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:AEROSOL CAN

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS & BASES, SELECTED AMINES.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, SOURCES OF
IGNITION, HOT METAL SURFACES, DIRECT SUNLIGHT.
Hazardous Decomposition Products:WHEN HEATED: MAY EMIT FUMES, CO, CO2,
UNIDENTIFIED ORGANIC COMPOUND.

Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. PLACE IN NON-LEAKING CONTAINERS. DISPOSE OF ABSORBED
MATERIAL IAW/FEDERAL, STATE & LOCAL REGULATIONS. DON'T INCINERATE
IN CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.